| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Total Violations |
3 |
Date of Inspection |
03/28/2025 |
| Risk Violations Count |
2 |
Inspection Time |
01.7 |
| Arrival Time |
10:42 |
Recommended for License |
N/A |
| Travel Time |
00.2 |
Facility Closure |
NO |
|
Food Facility
21 LOCKS BREWING COMPANY OF MORRISVILLE |
Address
32 W BRIDGE ST STE 2
|
City/State
MORRISVILLE, PA |
Zip Code
19067 |
Telephone
(267) 797-5014 |
Facility ID #
24F072 |
Owner
UNLOCK THE CRAFT, LLC |
Purpose of Inspection
Reinspection |
License Type
Permanent |
Risk Category
2 |
|
FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
|
|
IN=in compliance
OUT=not in compliance
N/O=not observed
N/A=not applicable
|
|
COS=corrected on-site during inspection
R=repeat violation
|
|
|
| Compliance Status |
COS |
R |
| Demonstration of Knowledge |
| 1 |
OUT |
Certification by accredited program, compliance with Code, or correct responses |
|
|
| Employee Health |
| 2 |
IN |
Management awareness; policy present |
|
|
| 3 |
IN |
Proper use of reporting; restriction & exclusion |
|
|
| Good Hygienic Practices |
| 4 |
OUT |
Proper eating, tasting, drinking, or tobacco use |
|
|
| 5 |
IN |
No discharge from eyes, nose, and mouth |
|
|
| Preventing Contamination by Hazards |
| 6 |
IN |
Hands clean & properly washed |
|
|
| 7 |
IN |
No bare hand contact with RTE foods or approved alternate method properly followed |
|
|
| 8 |
IN |
Adequate handwashing facilities supplied & accessible |
|
|
| Approved Source |
| 9 |
IN |
Food obtained from approved source |
|
|
| 10 |
IN |
Food received at proper temperature |
|
|
| 11 |
IN |
Food in good condition, safe, & unadulterated |
|
|
| 12 |
N/A |
Required records available: shellstock tags, parasite destruction |
|
|
| Protection from Contamination |
| 13 |
IN |
Food separated & protected |
|
|
| 14 |
IN |
Food-contact surfaces: cleaned & sanitized |
|
|
| 15 |
IN |
Proper disposition of returned, previously served, reconditioned, & unsafe food |
|
|
|
|
| Compliance Status |
COS |
R |
| Potentially Hazardous Food Time/Temperature |
| 16 |
IN |
Proper cooking time & temperature |
|
|
| 17 |
IN |
Proper reheating procedures for hot holding |
|
|
| 18 |
IN |
Proper cooling time & temperature |
|
|
| 19 |
IN |
Proper hot holding temperature |
|
|
| 20 |
IN |
Proper cold holding temperature |
|
|
| 21 |
IN |
Proper date marking & disposition |
|
|
| 22 |
IN |
Time as a public health control; procedures & record |
|
|
| Consumer Advisory |
| 23 |
N/A |
Consumer advisory provided for raw or undercooked foods |
|
|
| Highly Susceptible Populations |
| 24 |
N/A |
Pasteurized foods used; prohibited foods not offered |
|
|
| Chemical |
| 25 |
N/A |
Food additives: approved & properly used |
|
|
| 26 |
IN |
Toxic substances properly identified, stored & used |
|
|
| Conformance with Approved Procedure |
| 27 |
N/A |
Compliance with variance, specialized process, & HACCP plan |
|
|
Risk factors are improper practices or procedures identified as the most
prevalent contributing factors of foodborne illness or injury. Public Health
Interventions are control measures to prevent foodborne illness or injury. * - Critical Item Requiring Immediate Action
|
|
| GOOD RETAIL PRACTICES |
Good Retail Practices are preventative measures to control the addition of pathogens,
chemicals, and physical objects into foods.
|
|
| Compliance Status |
COS |
R |
| Safe Food and Water |
| 28 |
IN |
Pasteurized eggs used where required |
|
|
| 29 |
IN |
Water & ice from approved source |
|
|
| 30 |
IN |
Variance obtained for specialized processing methods |
|
|
| Food Temperature Control |
| 31 |
IN |
Proper cooling methods used; adequate equipment for temperature control |
|
|
| 32 |
IN |
Plant food properly cooked for hot holding |
|
|
| 33 |
IN |
Approved thawing methods used |
|
|
| 34 |
IN |
Thermometer provided & accurate |
|
|
| 35 |
OUT |
Food properly labeled; original container |
|
|
| Prevention of Food Contamination |
| 36 |
IN |
Insects, rodents & animals not present; no unauthorized persons |
|
|
| 37 |
IN |
Contamination prevented during food preparation, storage & display |
|
|
| 38 |
IN |
Personal cleanliness |
|
|
| 39 |
IN |
Wiping cloths: properly used & stored |
|
|
| 40 |
IN |
Washing fruit & vegetables |
|
|
|
|
| Compliance Status |
COS |
R |
| Proper Use of Utensils |
| 41 |
IN |
In-use utensils: properly stored |
|
|
| 42 |
IN |
Utensils, equipment & linens: properly stored, dried & handled |
|
|
| 43 |
IN |
Single-use & single-service articles: properly stored & used |
|
|
| 44 |
IN |
Gloves used properly |
|
|
| Utensils, Equipment and Vending |
| 45 |
IN |
Food & non-food contact surfaces cleanable, properly designed, constructed, & used |
|
|
| 46 |
IN |
Warewashing facilities: installed, maintained, & used; test strips |
|
|
| 47 |
IN |
Non-food contact surfaces clean |
|
|
| Physical Facilities |
| 48 |
IN |
Hot & cold water available; adequate pressure |
|
|
| 49 |
IN |
Plumbing installed; proper backflow devices |
|
|
| 50 |
IN |
Sewage & waste water properly disposed |
|
|
| 51 |
IN |
Toilet facilities: properly constructed, supplied, & cleaned |
|
|
| 52 |
IN |
Garbage & refuse properly disposed; facilities maintained |
|
|
| 53 |
IN |
Physical facilities installed, maintained, & clean |
|
|
| 54 |
IN |
Adequate ventilation & lighting; designated areas used |
|
|
|
|
|
|
|
|
| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Date of Inspection |
03/28/2025 |
| Arrival Time |
10:42 |
| Recommended for License |
N/A |
| Facility Closure |
NO |
|
Facility
21 Locks Brewing Company of Morrisville |
Address
32 W BRIDGE ST STE 2
|
City/State
MORRISVILLE, PA |
Zip Code
19067 |
Telephone
(267) 797-5014 |
Facility ID #
24F072 |
Owner
Unlock the Craft, LLC |
Purpose of Inspection
Reinspection |
License Type
Permanent |
Risk Category
2 |
|
|
TEMPERATURE OBSERVATIONS
|
| Item/Location |
Temp |
Item/Location |
Temp |
Item/Location |
Temp |
| Ambient/Cafe Mini Refrigerator |
40 ° F |
Ambient/Bar Keg Cooler |
38 ° F |
Milk/Bar Keg Cooler |
41 ° F |
| Ambient/Kitchen Prep Unit |
41 ° F |
Roasted Reds/Kitchen Prep Unit |
38 ° F |
Ambient/Pizza Prep Unit |
40 ° F |
| Ambient/Walk-in Cooler |
40 ° F |
Tomato Sauce/Walk-in Cooler |
38 ° F |
|
|
|
|
|
|
|
|
|
| OBSERVATIONS AND CORRECTIVE ACTIONS |
Item
Number |
Violations cited in this report must be corrected within the time frames below.
|
|
*1
|
*There is no food safety manager certified by this Department (CFSM) on duty as required. A CFSM must be on duty at all times the facility is open and/or food is being prepared. A completed application (SA-71) for CFSM, or proof of enrollment in an approved safety class must be submitted to the Department. New Violation.
|
|
*4
|
*Upon arrival, observed food employee eating in front of the Main Prep Unit in the kitchen. An employee may not eat, drink, or use any form of tobacco in areas where the contamination of exposed food, clean equipment, utensils, linens, etc, can result. Keep all food and drink in designated areas only. New Violation.
|
|
35
|
Facility is reusing single-use food containers for in-house food prep and storage. Once a food container’s food product has been used or emptied, that original container shall not be used for other food storage. Facility must use a food-safe container that can be cleaned and sanitized. New Violation.
|
|
|
|
|
|
|
|
General Remarks
|
Notes:
As a reminder, Food employees shall clean their hands and exposed portions of their arms as follows to prevent the spread of harmful micro-organisms:
(1) Immediately before engaging in food preparation activities such as working with exposed food, working with clean equipment and utensils, and working with unwrapped single-service and single-use articles.
(2) After touching bare human body parts other than clean hands and clean, exposed portions of arms.
(3) After using the toilet room.
(4) After caring for or handling service animals or aquatic animals
(5) After coughing, sneezing, using a handkerchief or disposable tissue, using tobacco, eating or drinking.
(6) After handling soiled equipment or utensils.
(7) During food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing tasks.
(8) When switching between working with raw food and working with ready-to-eat food.
(9) Before donning gloves for working with food.
(10) After engaging in other activities that contaminate the hands, such as using cell phones and other personal items.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|